Roofing Problems solved by Thermaco Engineering

The following thumbnail photos illustrate thermal images of electrical, process and roofing problems. Click on the thumbnail for enlargement of the image. Contact us for more details. Full Index

1. infrared image of loose internal bushing on a transformer	2. real images of internal bushing problem	3. image of loose connection	4. real images of loose connection	5. infrared scan with Agema infrared camera

6. image of wet insulation on a built up roof	7. image of wet insulation adjacent to a soil vent	8. verification of moisture content	9. infrared photo of a loose jumper connection	10. loose lug connection of a high voltage switch

11. loose connection from a breaker to a fuse on both phases	12. first phase fuse top clip is loose	13. first phase fuse clip and bolts are loose on a breaker	14. third phase fuse top clip and lug for disconnect is defective	15. third phase fuse and lug connection on a breaker is loose

16. transformer bushing connection is loose internally	17. refractory lining on a rotating kiln is defective	18. defective 15 amp breaker found in a lighting panel	19. poor connection at the jaws of a switch	20. loose fuse holder on a high voltage fuse

21. wet fibreboard insulation panel on a flat roof	22. wet insulation found adjacent to a roof drain	23. wet fibrous glass insulation panel found in a roof	24. electrical disconnect panel, thermal image of the 1st phase incoming lug connection found to be loose	25. evaluation of refractory lining in a process kiln furnace

26. evaluation of refractory lining for a process gas breaching	27. infrared image of defective refractory lining for process vessels and breaching	28. defective refractory lining for an incinerator	29. loose lug connection on a starter in an electrical panel	30. defective knife blades in an electrical disconnect

31. loose fuse clips in an electrical panel	32. loose lug connection at top of an electrical breaker	33. defective elbow and bushing for a high voltage pad mount transformer	34. wet insulation found in a built up flat roof system.	35. loose lug connection on a high voltage switch

36. defective high voltage switch	37. heat loss around access doors on a gas breaching	38. refractory lining conditions for a process furnace and associated gas flue	39. heat loss for a boiler side wall casing	40. internal IR scan of a refinery process heater tubes

41. coke located on bottom tubes (light gray area) in a process refinery heater		For details contact: btessler@thermacoeng.com